What should my pinion angle be?
What should my pinion angle be?
between 1 and 3 degrees
According to Currie, the average car crafter should strive for between 1 and 3 degrees between the tailshaft of the transmission and driveshaft, and 1 to 3 degrees between the driveshaft and pinion. Furthermore, the two angles should be nearly equal (between 1 and 3 degrees), but always opposite (see crude diagram).
What is the maximum pinion angle?
In order to minimize power loss and vibration in an offset configuration, the pinion centerline and the transmission centerline need to be parallel. In general, the largest angle for racing applications should be 2 degrees and the centerlines should be parallel within a few 1/10 of a degree.
How much driveline angle is too much?
Ideally, both driveshaft-operating angles will be 1 to 3 degrees. Anything over 3 degrees at the rear axle will shorten your universal joint’s life and could create vibration. If your angle is larger than 3 degrees, you must make sure not to exceed max driveshaft RPM as shown on this Spicer table.
What does a bad pinion angle do?
So what symptoms would lead you to identifying bad pinion angle? Drive train vibration at speed, wheel hop and universal joint fatigue/failure are all good indicators. These things can come out of no where with suspension bushing failures, engine and transmission mount failures or even leaf spring fatigue and wrap.
Can wrong pinion angle cause vibration?
Pinion angle is one of the most important considerations on a lifted vehicle, but sadly it is often overlooked. The wrong angles can lead to horrible drive line vibrations, as well as premature failure of U-joints, driveshafts, pinion bearings and even transfer case output bearings.
Does pinion angle affect traction?
A wrong pinion angle that binds things up will cause traction problems and if the angle is changed so that it would relieve the binding then that would actually change the way the cars hooks, but that is the only case where a pinion change with out changing anything to do with the suspension would have any affect.
